Professional Design Mbr Membrane Bioreactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo
Professional Design Mbr Membrane Bioreactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo Detail:
Applications
●Production of mineral water, mountain spring water and other germ-free liquid.
●Drinking treatment of tap water, surface water, well water and river water.
●Pre-treatment of RO device.
●Treatment, recycle and reuse of industrial wastewater.
Filtration Performance
According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which? are? applied to various water? sources, the? product? is? proved to reach below filtration effects:
| Water?Composition | Filtering?Effect |
| Suspended Substances, Particles?>1um | Removal Rate?≥99% |
| SDI | ≤?3 |
| Virus, Bacteria | >4 log |
| Turbidity | <0.1NTU |
| TOC | Removal Rate?0-25% |
Above data is obtained when turbidity of feed water is less than 15NTU. The product is proved to reach the sanitary standards of drinking water by Health Department of Guangdong Province. Approval number is YUE WEI SHUI ZI 2014?S1671.
Product Parameters
Product Appearance
Figure 1 Product Dimensions
Technical Parameters
| Structure | Inside-out |
| Membrane?Material | Modified?PVC |
| MWCO | 100K Dalton |
| Nominal Membrane Area | 16.5m2 |
| Membrane?ID/OD | 1.0mm/1.8mm |
| Module Dimensions | Φ180mm×1382mm |
| Connector?Dimensions | DN25 Female Thread |
Application Data
| Pure?Water?Flux | 7,000L/H?(0.15MPa, 25oC) |
| Designed?Flux | 35-100L/H?(0.15MPa, 25oC) |
| Operating?Pressure | ≤0.2MPa |
| Maximum Trans Membrane?Pressure | 0.2MPa |
| Maximum Operating Temperature | 45oC |
| Operating PH Range | 4-10 |
| Washing PH Range | 2-12 |
| Operating?Mode | Cross-flow/Dead-end Filtration |
Feed Water Requirements
A security filter, precision <50 micron, should be set as pretreatment of UF, in case of? blockage caused by large particles? in? raw water. Attention: UF membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.
| Feed?Water?Turbidity | ≤15NTU |
| Oil & Grease | ≤2mg/L |
| Feed?Water?SS | ≤20mg/L |
| Total?Iron | ≤1mg/L |
| Continuous Feeding Residual?Chlorine | ≤5ppm |
| COD | Suggested?≤500mg/L |
Component Material
| Component | Material |
| Hollow?Fiber?Membrane | Modified?PVC |
| Potting Material | Epoxy?Resins |
| Membrane?Housing | SUS304 |
Typical Operating Parameters
| Maximum Backwashing Pressure | 0.2MPa | |
| Backwashing?Flow?Rate | 100-150L/m2 .h | |
| Backwashing?Frequency | Every?30-60 minutes | |
| Backwashing?Duration | 30-60 seconds | |
| CEB Frequency | 0-4 times/day | |
| CEB Duration | 5-10 minutes | |
| CIP Frequency | 1-3 months | |
| General Washing Chemicals?： | ||
| Disinfection | 15ppm NaClO | |
| Organic?Contamination?Washing | 0.2% NaClo+0.1% NaOH | |
| Inorganic?Contamination?Washing | 1-2% Citric Acid?/0.2% HCl | |
Product detail pictures:
Related Product Guide:
We persist with the principle of quality 1st, assistance initially, continual improvement and innovation to meet the customers for your management and zero defect, zero complaints as the standard objective. To great our service, we present the products and solutions while using the very good high quality at the reasonable cost for Professional Design Mbr Membrane Bioreactor - UF Membrane Module PVC Ultrafiltration Membrane Module UFc80C Stainless Steel Housing Rain Water Treatment – Bangmo , The product will supply to all over the world, such as: kazan , Korea , Georgia , Our company insists on the purpose of takes service priority for standard, quality guarantee for the brand, do business in good faith, to offer skilled, rapid, accurate and timely service for you. We welcome old and new customers to negotiate with us. We are going to serve you with all sincerity!
By Modesty
from Montreal
- 2018.12.11 11:26
Product variety is complete, good quality and inexpensive, the delivery is fast and transport is security, very good, we are happy to cooperate with a reputable company!
By Carey
from Albania
- 2017.11.20 15:58
Write your message here and send it to us
Products categories
-
Factory wholesale Membrane Technology - MBR Me...
-
Factory wholesale Replacement Filter - MBR Mem...
-
Factory directly supply Filtration Filter - UF...
-
Original Factory Membrane Process In Water Trea...
-
Super Lowest Price Ultrafiltered Water - UF Me...
-
Chinese Professional Water Treatment Systems - ...