Original Factory Membrane Process In Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo

Short Description:

Product Detail

Product Tags

Feedback (2)

We insist on offering high-quality production with great enterprise concept, honest product sales and also the and fast service. it will bring you not only the superior quality solution and huge profit, but significant should be to occupy the endless market for Water Systems , Ultra Filtrate , Membrane Design , We have now four leading solutions. Our products are effective sold not only during the Chinese market, but also welcomed during the international industry.

Original Factory Membrane Process In Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo Detail:

Product?Overview

UFc50C? is? capillary? hollow? fiber? membrane? made? of? high? polymer? material, which is a separating product that will not have any phase change. The modified PVC material adopted to this product has good permeable rate, good mechanical strength, good? chemical? resistance? anti-pollution? ability,? MWCO? is? 100k? Dalton.? Membrane ID/OD? is? 1.0mm/1.8mm, ?filtering? direction? is? inside-out,? that? is? raw? water? flows inside the hollow fibers and, driven by differential pressure, permeates outwards so as to filter? bacteria, colloids, suspended substances,? microbes, and other? harmful substances.

Applications

Production of mineral water, mountain spring water and other germ-free liquid;

Drinking treatment of tap?water, surface?water, well?water?and?river?water;

Pre-treatment?of?RO?device;

Treatment, recycle and reuse of industrial wastewater

Filtration?Performance

According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which? are? applied to various water? sources, the? product? is? proved to reach below filtration effects:

Water?Composition	Filtering?Effect
Suspended Substances, Particles >1um	Removal Rate ≥99%
SDI	≤?3
Virus, Bacteria	>4 log
Turbidity	<0.1NTU
TOC	Removal Rate?0-25%

Above data is obtained when turbidity of feed water is less than 15NTU. The product? is? proved? to? reach? the? sanitary? standards? of? drinking? water? by ?Health Department? of? Guangdong? Province.? Approval? number? is? YUE? WEI? SHUI? ZI? 2014S1671.

Product?Parameters

Product?Appearance

svdd
Figure 1 Product Dimensions

Inner?Filter

bfd

Figure 2 Inner Filter Dimensions

Technical?Parameters:

Structure	Inside-out
Membrane?Material	Modified?PVC
MWCO	100K Dalton

Nominal Membrane Area	5.4m
Membrane?ID/OD	1.0mm/1.8mm
Module Dimensions	Φ105mm×?1110mm
Connector Dimensions	3/4” Female Thread

Application?Data:

Pure?Water?Flux	1,700L/H (0.15MPa, 25oC)
Designed?Flux	35-100L/H (0.15MPa, 25oC)
Operating?Pressure	≤0.2MPa
Maximum Trans Membrane?Pressure	0.2MPa
Maximum Operating Temperature	45oC
Operating PH Range	4-10
Washing PH Range	2-12
Operating?Mode	Cross-flow/Dead-end Filtration

Feed?Water Requirements:

A security filter, precision <50 micron, should be set as pretreatment of UF, in case of? blockage caused? by? large? particles? in? raw water. Attention:? UF? membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.

Feed?Water?Turbidity	≤15NTU
Oil & Grease	≤2mg/L
Feed?Water?SS	≤20mg/L
Total?Iron	≤1mg/L
Continuous Feeding Residual Chlorine	≤5ppm
COD	Suggested ≤500mg/L

Component?Material:

Component	Material
Hollow?Fiber?Membrane	Modified?PVC
Potting Material	Epoxy?Resins
Membrane?Housing	SUS304

Typical?Operating?Parameters:

Maximum Backwashing Pressure		0.2MPa
Backwashing?Flow?Rate		100-150L/m2 .h
Backwashing?Frequency		Every?30-60 minutes
Backwashing?Duration		30-60 seconds
CEB Frequency		0-4 times/day
CEB Duration		5-10 minutes
CIP Frequency		1-3 months
General Washing Chemicals ：
Disinfection	15ppm NaClO
Organic?Contamination?Washing	0.2% NaClo+0.1% NaOH
Inorganic?Contamination?Washing	1-2% Citric Acid /0.2% HCl

Product detail pictures:

Related Product Guide:

It is our responsibility to meet your needs and efficiently serve you. Your satisfaction is our satisfactory reward. We are looking forward to your visit for joint growth for Original Factory Membrane Process In Water Treatment - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo , The product will supply to all over the world, such as: Islamabad , Russia , Paris , During in 11 years,We have participated in more than 20 exhibitions,obtains the high praise from each customer. Our company always aim to provide the customer products with lowest price. We are making great efforts to achieve this win-win situation and sincerely welcome you to join us. Join us, show your beauty. We will always be your first choice. Trust us, you will never lose heart.

Fiber Membrane