Factory directly supply Filtration Filter - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo
Factory directly supply Filtration Filter - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo Detail:
Product?Overview
UFc50C? is? capillary? hollow? fiber? membrane? made? of? high? polymer? material, which is a separating product that will not have any phase change. The modified PVC material adopted to this product has good permeable rate, good mechanical strength, good? chemical? resistance? anti-pollution? ability,? MWCO? is? 100k? Dalton.? Membrane ID/OD? is? 1.0mm/1.8mm, ?filtering? direction? is? inside-out,? that? is? raw? water? flows inside the hollow fibers and, driven by differential pressure, permeates outwards so as to filter? bacteria, colloids, suspended substances,? microbes, and other? harmful substances.
Applications
Production of mineral water, mountain spring water and other germ-free liquid;
Drinking treatment of tap?water, surface?water, well?water?and?river?water;
Pre-treatment?of?RO?device;
Treatment, recycle and reuse of industrial wastewater
Filtration?Performance
According to the service conditions of modified PVC hollow fiber ultrafiltration membrane which? are? applied to various water? sources, the? product? is? proved to reach below filtration effects:
| Water?Composition | Filtering?Effect |
| Suspended Substances, Particles >1um | Removal Rate ≥99% |
| SDI | ≤?3 |
| Virus, Bacteria | >4 log |
| Turbidity | <0.1NTU |
| TOC | Removal Rate?0-25% |
Above data is obtained when turbidity of feed water is less than 15NTU. The product? is? proved? to? reach? the? sanitary? standards? of? drinking? water? by ?Health Department? of? Guangdong? Province.? Approval? number? is? YUE? WEI? SHUI? ZI? 2014S1671.
Product?Parameters
Product?Appearance
Figure 1 Product Dimensions
Inner?Filter
Figure 2 Inner Filter Dimensions
Technical?Parameters:
| Structure | Inside-out |
| Membrane?Material | Modified?PVC |
| MWCO | 100K Dalton |
| Nominal Membrane Area | 5.4m |
| Membrane?ID/OD | 1.0mm/1.8mm |
| Module Dimensions | Φ105mm×?1110mm |
| Connector Dimensions | 3/4” Female Thread |
Application?Data:
| Pure?Water?Flux | 1,700L/H (0.15MPa, 25oC) |
| Designed?Flux | 35-100L/H (0.15MPa, 25oC) |
| Operating?Pressure | ≤0.2MPa |
| Maximum Trans Membrane?Pressure | 0.2MPa |
| Maximum Operating Temperature | 45oC |
| Operating PH Range | 4-10 |
| Washing PH Range | 2-12 |
| Operating?Mode | Cross-flow/Dead-end Filtration |
Feed?Water Requirements:
A security filter, precision <50 micron, should be set as pretreatment of UF, in case of? blockage caused? by? large? particles? in? raw water. Attention:? UF? membrane material is macromolecular organic plastics, raw water must not contain any organic solvents.
| Feed?Water?Turbidity | ≤15NTU |
| Oil & Grease | ≤2mg/L |
| Feed?Water?SS | ≤20mg/L |
| Total?Iron | ≤1mg/L |
| Continuous Feeding Residual Chlorine | ≤5ppm |
| COD | Suggested ≤500mg/L |
Component?Material:
| Component | Material |
| Hollow?Fiber?Membrane | Modified?PVC |
| Potting Material | Epoxy?Resins |
| Membrane?Housing | SUS304 |
Typical?Operating?Parameters:
| Maximum Backwashing Pressure | 0.2MPa | |
| Backwashing?Flow?Rate | 100-150L/m2 .h | |
| Backwashing?Frequency | Every?30-60 minutes | |
| Backwashing?Duration | 30-60 seconds | |
| CEB Frequency | 0-4 times/day | |
| CEB Duration | 5-10 minutes | |
| CIP Frequency | 1-3 months | |
| General Washing Chemicals ： | ||
| Disinfection | 15ppm NaClO | |
| Organic?Contamination?Washing | 0.2% NaClo+0.1% NaOH | |
| Inorganic?Contamination?Washing | 1-2% Citric Acid /0.2% HCl | |
Product detail pictures:
Related Product Guide:
As for aggressive price ranges, we believe that you will be searching far and wide for anything that can beat us. We can easily state with absolute certainty that for such high-quality at such price ranges we're the lowest around for Factory directly supply Filtration Filter - UF Membrane Module PVC Ultrafiltration Membrane Module UFc50C Stainless Steel Housing Household Water Purification – Bangmo , The product will supply to all over the world, such as: USA , Grenada , Jordan , There are advanced producing & processing equipment and skilled workers to ensure the merchandise with high quality. We've got found an excellent before-sale, sale, after-sale service to ensure the customers that could rest assured to make orders. Until now our merchandise are now moving on fast and very popular in South America, East Asia, the Middle east, Africa, etc.
By Sally
from Salt Lake City
- 2018.09.19 18:37
The company has rich resources, advanced machinery, experienced workers and excellent services, hope you keep improving and perfecting your products and service, wish you better!
By Mignon
from kazan
- 2017.10.27 12:12
Products categories
-
Reliable Supplier Membrane Bioreactor Design - ...
-
Newly Arrival Uf Membrane Use - UF Membrane Mo...
-
Super Purchasing for Uf Membrane Water Purifier...
-
factory low price Cross Flow Filtration System ...
-
Special Design for Ultrafiltration Water Filter...
-
Hot-selling Ultrafiltration Membrane Filter - ...